Optimization of the Mixing in a Gas-lift Anaerobic Digester of Municipal Wastewater Sludge

Document Type : Research Article-en

Authors

• D. Baveli Bahmaei ¹
• Y. Ajabshirchy ²
• Sh. Abdollahpour ²
• S. Abdanan Mehdizadeh ³

¹ PhD Student, Department of Biosystems Engineering, Faculty of Agriculture, University of Tabriz, Tabriz, Iran

² Department of Biosystems Engineering, Faculty of Agriculture, University of Tabriz, Tabriz, Iran

³ Department of Mechanics of Biosystems Engineering, Faculty of Agricultural Engineering and Rural Development, Agricultural Sciences and Natural Resources University of Khuzestan, Ahvaz, Iran

https://doi.org/10.22067/jam.2023.83626.1182

Abstract

This research aims to optimize the mixing process in gas-lift anaerobic digesters of municipal sewage sludge since mixing and maintaining uniform contact between methanogenic bacteria and nutrients is essential. Wastewater municipal sludge sampling was performed at the Ahvaz West treatment plant (Chonibeh, Iran) during the summer of 2022. A Computational Fluid Dynamics (CFD) model was implemented to simulate, optimize, and confirm the simulation process using ANSYS Fluent software 19.0. The velocity of the inlet-gas into the digester was determined and a draft tube and a conical hanging baffle were added to the digester design. Different inlet-gas velocities were investigated to optimize the mixing in the digester. Furthermore, turbulence kinetic energy and other evaluation indexes related to the sludge particles such as their velocity, velocity gradient, and eddy viscosity were studied. The optimal inlet-gas velocity was determined to be 0.3 ms^-1. The simulation results were validated using the Particle Image Velocimetry (PIV) method and the correlation between CFD and PIV contours was statistically sufficient (98.8% at the bottom corner of the digester’s wall). The results showed that the model used for simulating, optimizing, and verifying the simulation process is valid. It can be recommended for gas-lift anaerobic digesters with the following specifications: cylindrical tank with a height-to-diameter ratio of 1.5, draft tube-to-digester diameter ratio of 0.2, draft tube-to-fluid height ratio of 0.75, the conical hanging baffle distance from the fluid level equal to 0.125 of the fluid height, and its outer diameter-to-digester diameter of 2/3.

Keywords

• Computational Fluid Dynamics (CFD)
• Digestion
• Particles Image Velocimetry (PIV)
• Simulation

Main Subjects

• Bioenergy

©2023 The author(s). This is an open access article distributed under Creative Commons Attribution 4.0 International License (CC BY 4.0).

References

1. ANSYS-Fluent Inc. (2008). Fluent 12.0. ANSYS-Fluent Inc, Lebanon, N.H.
2. Baveli Bahmaei, D., Ajabshirchi, Y., Abdollah poor, Sh., & Abdanan Mehdizadeh, S. (2022). Step-by-step Simulation of Gas-lift Anaerobic Digester of Municipal Wastewater Sludge. Iranian Journal of Biosystem Engineering, 53(1), 91-108. (In Persian). https://doi.org/10.22059/ijbse.2022.328388.665428
3. Celik, I. B., Ghia, U., Roache, P. J., Freitas, C. J., Coleman, H., & Raad, P. E. (2008). Procedure for estimation and reporting of uncertainty due to discretization in CFD applications. Journal of Fluids Engineering, 130, 078001. https://doi.org/10.1115/1.2960953
4. Dapelo, D., Alberini, F., & Bridgeman, J. (2015). Euler-Lagrange CFD modeling of unconfined gas mixing in anaerobic digestion. Water Researches, 85, 497-511. https://doi.org/10.1016/j.watres.2015.08.042
5. Dapelo, D., & Bridgeman, J. (2018). Euler-Lagrange Computational Fluid Dynamics simulation of a full-scale unconfined anaerobic digester for wastewater sludge treatment. Advances in Engineering Software, 117, 153-169. https://doi.org/10.1016/j.advengsoft.2017.08.009
6. Dawkins, M. S., Cain, R., & Roberts, S. J. (2012). Optical flow, flock behavior and chicken welfare. Animal Behavior, 84(1), 219-223. https://doi.org/10.1016/j.anbehav.2012.04.036
7. Hu, Y., Zhang, Sh., Wang, X., Peng, X., Hu, F., Wang, Ch., Wu, J., Poncin, S., & Li, H. Z. (2021). Visualization of mass transfer in mixing processes in high solid anaerobic digestion using Laser Induced Fluorescence (LIF) technique. Waste Management, 127, 121-129. https://doi.org/10.1016/j.wasman.2021.04.038
8. Karim, Kh., Varma, R., Vesvikar, M., & Al-Dahhan, M. H. (2004). Flow pattern visualization of a simulated digester. Water Research, 38(17), 3659-3670. https://doi.org/10.1016/j.watres.2004.06.009
9. Karim, Kh., Klasson, K. T., Hoffmann, R., Drescher, S. R., DePaoli, D. W., & Al-Dahhan, M. H. (2005). Anaerobic digestion of animal waste: Effect of mixing. Bioresource Technology, 96(14), 1607-1612. https://doi.org/10.1016/j.biortech.2004.12.021
10. Karim, K., Thoma, G. J., & Al-Dahhan, M. H. (2007). Gas-lift digester configuration effects on mixing effectiveness. Water Researches, 41(14), 3051-3060. https://doi.org/10.1016/j.watres.2007.03.042
11. McFarland, M. J. (2001). Biosolids Engineering. McGraw-Hill Education, New York.
12. Menter, F. R. (1993). Zonal Two Equation k-cl, Turbulence Models for Aerodynamic Flows. 24th Fluid Dynamics Conference. Orlando, Florida.
13. Meynell, P. J. (1976). Methane: Planning a Digester. London: Prism Press: 55-57.
14. Raffel, M., Willert, C. E., & Kompenhans, J. (1998). Paeticle Image Velocimetry, A Practical Guide. Springer Verlage, first edition.
15. Sawyer, C. N., & Grumbling, A. M. (1960). Fundamental consideration in high-rate digestion. Inc. Sewage Engineering Division. ASCE, 86-92.
16. Stukenberg, J. R., Clark, J. H., Sandino, J., & Naydo, W. R. (1992). Egg-shaped digesters: from Germany to the U.S. Water Environment Technology, 4, 42-51.
17. U. EPA. (1979). Process design manual for sludge treatment and disposal, Center for environmental research in formation technology transfer. pp.
18. Varma, R., & Al-Dahhan, M. H. (2007). Effect of sparger design on hydrodynamics of a gas recirculation anaerobic bioreactor. Biotechnology Bioengineering, 98(6), 1146-1160. https://doi.org/10.1002/bit.21500
19. Vesvikar, M. S., & Al-Dahhan, M. (2016). Hydrodynamics investigation of laboratory-scale Internal Gas-lift loop anaerobic digester using non-invasive CAPRT technique. Biomass and Bioenergy, 84, 98-106. https://doi.org/10.1016/j.biombioe.2015.11.014
20. Wei, P., Uijttewaal, W., Spanjers, H., Lier, J. B., & Kreuk, M. (2023). Optimising flow and mixing in a full-scale gas-mixed anaerobic digester by integrating sludge rheological data using computational fluid dynamics. Chemical Engineering Journal, 468. https://doi.org/10.1016/j.cej.2023.143647
21. Wu, B. (2010). CFD simulation of gas and non-Newtonian fluid two-phase flow in anaerobic digesters. Water Research, 44(13), 3861-3874. https://doi.org/10.1016/j.watres.2010.04.043
22. Wu, B. (2014). CFD simulation of gas mixing in anaerobic digesters. Computers and Electronics in Agriculture, 109, 278-286. https://doi.org/10.1016/j.compag.2014.10.007
23. Yang, J., Yang, Y., Ji, X., Chen, Y., Guo, J., & Fang, F. (2015). Three-Dimensional Modeling of Hydrodynamics and Biokinetics in EGSB Reactor. Journal of Chemistry. https://doi.org/10.1155/2015/635281