The Efficiency of Cold Plasma Treatment on Aspergillus Niger Disinfection and Quality Properties Preservation of Grapes during the Post-harvest Period

Document Type : Research Article

Authors

• A. Khalaj ¹
• E. Ahmadi ¹
• S. Mirzaei ²
• F. Ghaemizadeh ³
• R. Abbaszadeh ⁴

¹ Department of Biosystems Engineering, Faculty of Agriculture, Bu-Ali Sina University, Hamadan, Iran

² Department of Plant Protection, Faculty of Agriculture, Bu-Ali Sina University, Hamadan, Iran

³ Department of Horticultural Science, Faculty of Agriculture, Bu-Ali Sina University, Hamadan, Iran

⁴ Iranian Research Organization for Science and Technology, Tehran, Iran

https://doi.org/10.22067/jam.2023.84550.1191

Abstract

Introduction
Grape is a major horticultural crop with a high nutritional value in the world. The optimal geographic and climatic conditions in Iran have positioned it as one of the most important regions for grape cultivation in the world. Black rot, caused by Aspergillus niger, is a highly destructive fungal disease that affects the grapes by targeting wounded areas. It causes crushing of the grapes, the falling of berries, and reduces transportation and storage properties (Ponsone et al., 2011). Various methods, such as fumigating bunches with sulfur dioxide and storing them in a modified atmosphere, have been used to control fungal rot and prolong the shelf life of grapes. However, each method has its limitations. Grape fumigation with sulfur gas is harmful to human health (Duarte-Sierra et al., 2016) and the efficiency of modified atmospheric storage on rot control and maintaining the quality of grapes depends on the type of variety, storage temperature, and especially gas concentration (Himelrick, 2003).
Given the lack of efficiency in traditional methods, it is imperative to introduce modern techniques that can effectively disinfect microorganisms. These advanced methods offer several advantages, including the preservation of crop quality, an increase in crop shelf life, the promotion of good health, and substantial economic benefits. A technique of this type includes using non-thermal (cold) plasma (NTP) technology to eliminate food microorganisms (Bourke et al., 2018). The effect of cold plasma at atmospheric pressure on the reduction of bacterial populations in food products such as lettuce, tomato, strawberry, and cherry tomato has been reported (Bermúdez-Aguirre et al., 2013; Pasquali et al., 2016; Ziuzina et al., 2014). Research has shown that cold plasma can effectively inactivate Aspergillus in various orchard and agricultural products (Butscher et al., 2016; Ghorashi et al., 2020; Selcuk et al., 2008). The effect of cold plasma on the quality characteristics of the product during the post-harvest period has also been investigated. Blueberries treated with cold plasma for less than 15 minutes showed remarkable results: after 10 days, the fruit exhibited reduced lipid peroxidation and darkening, with no impact on the total anthocyanin content, pH, or firmness of the product (Hu et al., 2021). In a study by Rana et al. (2020), it was found that subjecting strawberries to 15 minutes of cold plasma with packaging after 5 days of storage at 25°C had no significant impact on pH, TSS, and moisture content of the fruit.
The review of the literature reveals the absence of research on fungal disease control and grape quality evaluation following the use of NTP. This study aims to investigate the efficiency of plasma treatment in reducing the infection with Aspergillus fungi, along with examining the physical, chemical, and mechanical properties of Fakhri grape.
Materials and Methods
This research was conducted as a completely randomized design in a factorial experiment at four plasma levels (0, 10, 20, and 40 s) and five storage periods (1, 2, 3, 4, and 5 weeks) with three replications at 4°C.  A plasma generator was first designed and manufactured in this study. A specifically designed and fabricated plasma application probe was also developed for grape berries. The individual grape berries were then sterilized with 1% sodium hypochlorite under a laminar hood for 2 minutes. Afterward, they were rinsed three times with sterile distilled water to remove any remaining disinfectant residue from their surfaces. Sterilized berries were immersed in Aspergillus spore suspension with 105 spores.ml^-1 concentration. Finally, all samples were dried on paper filters and prepared for different plasma treatment durations (0, 10, 20, and 40 s). The treated samples were stored at 4°C, and the infection percentage and microbial load were measured on a weekly basis. To assess the preservation quality, chemical parameters such as pH, TSS, and TA, physical parameters (color change and weight loss), and mechanical properties were measured every week. Additionally, thermal imaging was performed weekly.
Results and Discussion
Plasma application during storage significantly reduced the infection percentage and microbial load in Aspergillus-inoculated samples. At the end of the storage period, the infection percentage and microbial load in the 40-second plasma treatment were 5% and 2.5 CFU g^-1 respectively, while in the control group, the infection percentage was 100% and the microbial load was 4 CFU g^-1. At the end of the storage period, the lowest pH level in the plasma was observed for 40 s plasma. This could be attributed to effective contamination control, as fungal contamination leads to alkalization of the environment. The highest amount of TSS was also observed in control and 40 s plasma. But in the 10 and 20 s plasma treatment, the process of changes was gradual and not significant. The higher TSS level of control and 40 s plasma can be due to the weight loss caused by the spread of contamination and moisture leakage caused by damage to the tissue. This decrease in moisture leads to an apparent increase in the TSS index. Research has shown that plasma primarily affects the surface characteristics of products, and when applied with the appropriate voltage and duration, it does not alter the internal chemical properties (Hu et al., 2021). Over time, weight loss increased in all treatments. This increasing trend during the storage period is higher in control and 40 s plasma compared to 10 and 20 s plasma. Therefore, the weight loss in the control can be due to the spread of contamination and aging of the product over time. However, the weight loss in the 40-second plasma treatment can be due to the destruction of the fruit tissue caused by longer duration of the plasma application.
In the current research, by increasing the duration of plasma application to 40 s, a significant decrease in L*, a*, and b* indices and an overall change in the color of the product was observed. Research shows that in blueberries, inappropriate duration of plasma treatment causes the loss of wax on the fruit surface and leads to darkening of the product (Hu et al., 2021). The highest and lowest changes in temperature drop were observed in the control treatment (5°C) and 10 and 20 s plasma (3 and 3.5°C, respectively). According to research, an increase in fungal contamination leads to a decrease in humidity, increases weight loss, and subsequently a decrease in product temperature. A decline in mechanical characteristics was noted for the control and plasma treated samples during the storage period. The lowest value for indicators was observed in the 40 s plasma treatment. However, no significant difference was observed in samples treated with plasma for less than 20 seconds compared to the control group up to the middle of the storage period. According to a report by Misra et al. (2014), plasma application can reduce tissue softness. Therefore, optimizing its plasma duration and intensity is very important (Pan et al., 2021).
 Conclusion
Our experiments aimed to investigate the effect of NTP treatment on controlling Aspergillus infections while preserving the quality properties of Fakhri grapes. The obtained results are important for two main reasons. Firstly, an innovative probe was designed for plasma applications, specifically tailored to the shape and size of individual grapes in order to thoroughly cover them with plasma. Secondly, application of plasma was carried out for the first time and yielded valuable results, indicating that this technique can control fungal infections and preserve the chemical, physical, and mechanical properties of grapes.

Keywords

• Chemical properties
• Cold plasma
• Mechanical properties
• Microbial load
• Physical properties

Main Subjects

• Post-harvest technologies

©2024 The author(s). This is an open access article distributed under Creative Commons Attribution 4.0 International License (CC BY 4.0)

References

1. Aday, M. S., Büyükcan, M. B., Temizkan, R., & Caner, C. (2013). Role of ozone concentrations and exposure times in extending the shelf life of strawberry. Ozone: Science and Engineering, 36(1), 43-56. https://doi.org/10.1080/01919512.2013.833851
2. Arfaoui, M., Vallance, J., Bruez, E., Rezgui, A., Melki, I., Chebil, S., & Rey, P. (2019). Isolation, identification, and in vitro characterization of grapevine rhizobacteria to control ochratoxigenic Aspergillus spp. on grapes. Biological Control, 129, 201-211. https://doi.org/10.1016/j.biocontrol.2018.10.019
3. Bermúdez-Aguirre, D., Wemlinger, E., Pedrow, P., Barbosa-Cánovas, G., & Garcia-Perez, M. (2013). Effect of atmospheric pressure cold plasma (APCP) on the inactivation of Escherichia coli in fresh produce. Food Control, 34(1), 149-157. https://doi.org/10.1016/j.foodcont.2013.04.022
4. Bourke, P., Ziuzina, D., Boehm, D., Cullen, P. J., & Keener, K., (2018). The potential of cold plasma for safe and sustainable food production. Trends in Biotechnology, 36(6), 615-626. https://doi.org/10.1016/j.tibtech.2017.11.001
5. Butscher, D., Zimmermann, D., Schuppler, M., & Von Rohr, P. R. (2016). Plasma inactivation of bacterial endospores on wheat grains and polymeric model substrates in a dielectric barrier discharge. Food Control, 60, 636-645. https://doi.org/10.1016/j.foodcont.2015.09.003
6. Chelladurai, V., Jayas, D. S., & White, N. D. G. (2010). Thermal imaging for detecting fungal infection in stored wheat. Journal of Stored Products Research, 46(3), 174-179. https://doi.org/10.1016/j.jspr.2010.04.002
7. Crisosto, C. H. (2002). Mitchell, F.G. Postharvest Handling Systems: Table grapes. In Postharvest Technology of Horticultural Crops; Kader, A.A., Ed.; University of California Agricultural and Natural Resources Pub: Davis, CA, USA. pp. 357-363.
8. Dasan, G. B., & Boyaci, I. H. (2018). Effect of cold atmospheric plasma on inactivation of Escherichia coli and physicochemical properties of apple, orange, tomato juices, and sour cherry nectar. Food and Bioprocess Technology, 11(2), 334-343. https://doi.org/10.1007/s11947-017-2014-0
9. De Simone, N., Pace, B., Grieco, F., Chimienti, M., Tyibilika, V., Santoro, V., & Russo, P. (2020). Botrytis cinerea and table grapes: A review of the main physical, chemical, and bio-based control treatments in post- harvest. Foods, 9(9), 1138. https://doi.org/10.3390/foods9091138
10. Dobrynin, D., Fridman, G., Friedman, G., & Fridman, A. (2009). Physical and biological mechanisms of direct plasma interaction with living tissue. New Journal of Physics, 11, 115020. https://doi.org/10.1088/1367-2630/11/11/115020
11. Dong, X. Y., & Yang, Y. L. (2019). A novel approach to enhance blueberry quality during storage using cold plasma at atmospheric air pressure. Food and Bioprocess Technology, 12(8), 1409-1421. https://doi.org/10.1007/s11947-019-02305-y
12. Duarte-Sierra, A., Aispuro-Hernández, E., Vargas-Arispuro, I., Islas-Osuna, M. A., González-Aguilar, G. A., & Martínez-Téllez, M. Á. (2016). Quality and PR geneexpression of table grapes treated with ozone and sulfur dioxide to control fungal decay. Journal of Science and Food Agriculture, 96, 2018-2024. https://doi.org/10.1002/jsfa.7312
13. FAO. (2021). http://www.faostat.fao.org/. Access date 24 March 2023.
14. Fernandez, A., Noriega, E., & Thompson, A. (2013). Inactivation of Salmonella enterica serovar Typhimurium on fresh produce by cold atmospheric gas plasma technology. Food Microbiology, 33(1), 24-29. https://doi.org/10.1016/j.fm.2012.08.007
15. Gabler, F. M., & Smilanick, J. L. (2001). Postharvest control of table grape gray mold on detached berries with carbonate and bicarbonate salts and disinfectants. American Journal of Enology and Viticulture, 52, 12-2. https://doi.org/10.5344/ajev.2001.52.1.12
16. Ghorashi, A. H., Tasouji, M. R., & Kargarian, A. (2020). Optimum cold plasma generating device for treatment of Aspergillus flavus from nuts surface. Journal of Food Science and Technology, 57, 3988-3994. https://doi.org/10.1007/s13197-020-04429-y
17. Hellebrand, H. J., Beuche, H., & Linke, M. (2002). Thermal imaging: A promising high-tec method in agriculture and horticulture. Physical Methods in Agriculture: Approach to Precision and Quality, 411-427. https://doi.org/10.1007/978-1-4615-0085-8_22
18. Himelrick, D. G. (2003). Handling, storage and postharvest physiology of Muscadine grapes: A review. Small Fruits Review, 2(4), 45-62. https://doi.org/10.1300/J301v02n04_06
19. Hu, X., Sun, H., Yang, X., Cui, D., Wang, Y., Zhuang, J., & Jiao, Z. (2021). Potential use of atmospheric cold plasma for postharvest preservation of blueberries. Postharvest Biology and Technology, 179, 111564. https://doi.org/10.1016/j.postharvbio.2021.111564
20. Jayasena, D. D., Kim, H. J., Yong, H. I., Park, S., Kim, K., Choe, W., & Jo, C. (2015). Flexible thin-layer dielectric barrier discharge plasma treatment of pork butt and beef loin: Effects on pathogen inactivation and meat-quality attributes. Food Microbiology, 46, 51-57. https://doi.org/10.1016/j.fm.2014.07.009
21. Kader, A. A., & Watkins, C. B. (2000). Modified atmosphere packaging-toward 2000 and beyond. HortTechnology, 10(3), 483-486. https://doi.org/10.21273/HORTTECH.10.3.483
22. Kasfi, K., Taheri, P., Jafarpour, B., & Tarighi, S. (2018). Characterization of antagonistic microorganisms against Aspergillus spp. from grapevine leaf and berry surfaces. Journal of Plant Pathology, 100, 179-190. https://doi.org/10.1007/s42161-018-0042-x
23. Khodamoradi, S., & Ahmadi, E. (2019). Effect of Chitosan Coating on Physical, Mechanical and Chemical Properties of Grapes during Storage. Journal of Agricultural Machinery, 9(2), 347-364. (In Persian). https://doi.org/10.22067/jam.v9i2.69423
24. Lacombe, A., Niemira, B. A., Gurtler, J. B., Fan, X. T., Sites, J., Boyd, G., & Chen, H. Q. (2015). Atmospheric cold plasma inactivation of aerobic microorganisms on blueberries and effects on quality attributes. Food Microbiology, 46, 479-484. https://doi.org/10.1016/ j.fm.2014.09.010
25. Lu, S. L., Yang, X. Z., Li, X. H., Shen, L. M., & Ma, H. Y. (2013). Effect of sulfur dioxide treatment on storage quality and SO₂ residue of victoria grape. Advanced Materials Research, 798, 1033-1036. https://www.scientific.net/AMR.798-799.1033
26. Ma, R. N., Yu, S., Tian, Y., Wang, K. L., Sun, C. D., Li, X., Zhang, J., Chen, K. S., & Fang, J. (2016). Effect of non-thermal plasma-activated water on fruit decay and quality in postharvest Chinese bayberries. Food Bioprocess Technology, 9(11), 1825-1834. https://doi.org/10.1007/s11947-016-1761-7
27. Meng, X. H., Qin, G. Z., & Tian, S. P. (2010). Influences of preharvest spraying Cryptococcus laurentii combined with postharvest chitosan coating on postharvest diseases and quality of table grapes in storage. LWT-Food Science and Technology, 43(4), 596-601. https://doi.org/10.1016/j.lwt.2009.10.007
28. Min, S. C., Roh, S. H., Niemira, B. A., Boyd, G., Sites, J. E., Fan, X., Sokorai, K., & Jin, T. Z. (2018). In-package atmospheric cold plasma treatment of bulk grape tomatoes for microbiological safety and preservation. Food Research International, 108, 378-386. https://doi.org/10.1016/j.foodres.2018.03.033
29. Misra, N. N., Keener, K. M., Bourke, P., Mosnier, J. P., & Cullen, P. J. (2014). In-package atmospheric pressure cold plasma treatment of cherry tomatoes. Journal of Bioscience and Bioengineering, 118(2), 177-182. https://doi.org/10.1016/j.jbiosc.2014.02.005
30. Olivas, G. I., & Barbosa-Cánovas, G. (2009). Edible films and coatings for fruits and vegetables:  In: Huber, K., Embuscado, M. (eds), Edible films and coatings for food applications, Springer, New York, pp. 211-244. NY. https://doi.org/10.1007/978-0-387-92824-1_7
31. Oliver, R. P., & Hewitt, H. G. (2014). Fungicides in crop protection. Published by Cabi.
32. Ott, L. C., Appleton, H. J., Shi, H., Keener, K., & Mellata, M. (2021). High voltage atmospheric cold plasma treatment inactivates Aspergillus flavus spores and deoxynivalenol toxin. Food Microbiology, 95, 103669. https://doi.org/10.1016/j.fm.2020.103669
33. Pan, Y. W., Cheng, J. H., & Sun, D. W. (2021). Inhibition of fruit softening by cold plasma treatments: Affecting factors and applications. Critical Reviews in Food Science and Nutrition, 61(12), 1935-1946. https://doi.org/10.1080/10408398.2020.1776210
34. Pasquali, F., Stratakos, A. C., Koidis, A., Berardinelli, A., Cevoli, C., Ragni, L., Mancusi, R., Manfreda, G., & Trevisani, M. (2016). Atmospheric cold plasma process for vegetable leaf decontamination: A feasibility study on radicchio (red chicory, Cichorium intybus). Food Control, 60, 552-559. https://doi.org/10.1016/j.foodcont.2015.08.043
35. Pezzuto, J. M. (2008). Grapes and human health: a perspective. Journal of Agricultural and Food Chemistry, 56(16), 6777-6784. https://pubs.acs.org/doi/abs/10.1021/jf800898p
36. Ponsone, M. L., Chiotta, M. L., Combina, M., Dalcero, A., & Chulze, S. (2011). Biocontrol as a strategy to reduce the impact of ochratoxin A and Aspergillus section Nigri in grapes. International Journal of Food Microbiology, 151(1), 70-77. https://doi.org/10.1016/j.ijfoodmicro.2011.08.005
37. Ramazzina, I., Berardinelli, A., Rizzi, F., Tappi, S., Ragni, L., Sacchetti, G., & Rocculi, P. (2015). Effect of cold plasma treatment on physico-chemical parameters and antioxidant activity of minimally processed kiwifruit. Postharvest Biology and Technology, 107, 55-65. https://doi.org/10.1016/j.postharvbio.2015.04.008
38. Rana, S., Mehta, D., Bansal, V., Shivhare, U. S., & Yadav, S. K. (2020). Atmospheric cold plasma (ACP) treatment improved in-package shelf-life of strawberry fruit. Journal of Food Science and Technology, 57, 102-112. https://doi.org/10.1007/s13197-019-04035-7
39. Rux, G., Mahajan, P., Linke, M., Saengerlaub, S., Pant, A., Caleb, O., & Geyer, M. (2015). Application of humidity-regulating trays for packaging of fresh strawberry and tomato. In III International Conference on Fresh-Cut Produce: Maintaining Quality and Safety, 1141, 263-268. https://doi.org/10.17660/ActaHortic.2016.1141.32
40. Sanchez-Ballesta, M. T., Alvarez, I., Escribano, M. I., Merodio, C., & Romero, I. (2020). Effect of high CO₂ levels and low temperature on stilbene biosynthesis pathway gene expression and stilbenes production in white, red and black table grape cultivars during postharvest storage. Plant Physiology and Biochemistry, 151, 334-341. https://doi.org/10.1016/j.plaphy.2020.03.049
41. Selcuk, M., Oksuz, L., & Basaran, P. (2008). Decontamination of grains and legumes infected with Aspergillus and Penicillum spp. by cold plasma treatment. Bioresource Technology, 99(11), 5104-5109. https://doi.org/10.1016/j.biortech.2007.09.076
42. Song, A. Y., Oh, Y. J., Kim, J. E., Song, K. B., Oh, D. H., & Min, S. C. (2015). Cold plasma treatment for microbial safety and preservation of fresh lettuce. Food Science and Biotechnolgy, 24, 1717-1724. https://doi.org/10.1007/s10068-015-0223-8
43. Tappi, S., Gozzi, G., Vannini, L., Berardinelli, A., Romani, S., Ragni, L., & Rocculi, P. (2016). Cold plasma treatment for fresh-cut melon stabilization. Innovative Food Science and Emerging Technologies, 33, 225. https://doi.org/10.1016/j.ifset.2015.12.022
44. Varith, J., Hyde, G. M., Baritelle, A. L., Fellman, J. K., & Sattabongkot, T. (2003). Noncontact bruise detection in apples by thermal imaging. Innovative Food Science & Emerging Technologies, 4(2), 211-218. https://doi.org/10.1016/S1466-8564(03)00021-3
45. Wiktor, A., Hrycak, B., Jasinski, M., Rybak, K., Kieliszek, M., Krasniewska, K., & Witrowa- Rajchert, D. (2020). Impact of atmospheric pressure microwave plasma treatment on quality of selected spices. Applied Sciences-Basel, 10 (19), 6815. https://doi.org/10.3390/app10196815
46. Xu, H. B., Ma, R. N., Zhu, Y. P., Du, M. R., Zhang, H., & Jiao, Z. (2020). A systematic study of the antimicrobial mechanisms of cold atmospheric-pressure plasma for water disinfection. Science of Total Environment, 703, 134965 https://doi.org/10.1016/j. scitotenv.2019.134965
47. Xu, H. B., Zhu, Y. P., Du, M. R., Wang, Y. Q., Ju, S. Y., Ma, R. N., & Jiao, Z. (2021). Subcellular mechanism of microbial inactivation during water disinfection by cold atmospheric-pressure plasma. Water Research, 188, 116513 https://doi.org/10.1016/j.watres.2020.116513
48. Zahavi, T., Cohen, L., Weiss, B., Schena, L., Daus, A., Kaplunov, T., & Droby, S. (2000). Biological control of Botrytis, Aspergillus and Rhizopus rots on table and wine grapes in Israel. Postharvest Biology and Technology, 20(2), 115-124. https://doi.org/10.1016/S0925-5214(00)00118-6
49. Zhou, D., Li, T., Cong, K., Suo, A., & Wu, C. (2022). Influence of cold plasma on quality attributes and aroma compounds in fresh-cut cantaloupe during low temperature storage. Food Science and Technology, 154, 112893. https://doi.org/10.1016/j.lwt.2021.112893
50. Ziuzina, D., Misra, N. N., Han, L., Cullen, P. J., Moiseev, T., Mosnier, J. P., & Bourke, P. (2020). Investigation of a large gap cold plasma reactor for continuous in-package decontamination of fresh strawberries and spinach. Innovative Food Science & Emerging Technologies, 59, 102229. https://doi.org/10.1016/j.ifset.2019.102229
51. Ziuzina, D., Patil, S., Cullen, P. J., Keener, K. M., & Bourke, P. (2014). Atmospheric cold plasma inactivation of Escherichia coli, Salmonella enterica serovar Typhimurium and Listeria monocytogenes inoculated on fresh produce. Food Microbiology, 42, 109-116. https://doi.org/10.1016/j.fm.2014.02.007