Evaluation of Dielectric Spectroscopy in Fusion with Vis-SWNIR Spectroscopy for the Measurement of Sugar Concentration in Sugarcane Stalk Samples

Document Type : Research Article

Authors

• M. Naderi-Boldaji
• M. Tohidi
• M. Ghasemi-Varnamkhasti

Department of Mechanical Engineering of Biosystems, Shahrekord University, Shahrekord, Iran

https://doi.org/10.22067/jam.2023.80620.1144

Abstract

Introduction
The development of portable devices for real-time quality assessment of sugarcane is an essential necessity in the agricultural and industrial technology of sugarcane production and processing. Attributes of sugarcane such as sugar concentration and water content can be utilized for this purpose. Near infrared (NIR) spectroscopy has been one of the most widely applied techniques for quality evaluation of sugarcane. However, NIR spectrophotometers in the full NIR wavelength range (up to 2500 nm) are expensive devices that are not readily available for portable applications. Short-wave NIR devices in the range of 1100 nm are available at lower costs but need to be evaluated for specific applications. On the other hand, dielectric spectroscopy has attracted the attention of researchers for quality evaluation of agricultural and food products. In a previous study, a parallel-plate capacitance sensor was developed and evaluated for non-destructive measurement of sugarcane Brix (total soluble solids) and Pol (sucrose concentration) as well as water content, in the frequency range of 0-10 MHz. The results showed excellent prediction models with root mean square errors smaller than 0.3 for Brix and Pol. This study aimed to develop and evaluate a dielectric sensor that can be extended for portable measurements on standing sugarcane stalk in comparison with short-wave NIR (SWNIR) spectroscopy to address how the fusion of the two methods may improve the accuracy of models for predicting sugarcane Brix.
Materials and Methods
A dielectric sensor in the form of a gadget was developed with metallic electrodes to encompass the sugarcane stalk samples. The dielectric sensor was excited with a sinusoidal voltage within 0-150 MHz frequency range by a function generator, and the conductive power through the electrodes was measured using a spectrum analyzer. 105 sugarcane stalk samples were prepared from seven sugarcane varieties and scanned with the dielectric sensor. The samples were also subjected to Vis-SWNIR radiation in the wavelength range of 400-1100 nm, and the reflectance spectra were captured. Reference Brix and water content of the samples were determined using a portable refractometer and oven-drying method, respectively. Regression analyses and artificial neural networks were performed on independent and combined data from dielectric and Vis-SWNIR spectroscopy to develop prediction models for Brix and water content.
Results and Discussion
Partial least squares regression on independent data sets of each instrument resulted in RMSE_P = 1.14 and RMSE_P = 1.88 for Brix using Vis-SWNIR and dielectric spectroscopy, respectively. Moreover, data fusion of dielectric and Vis-SWNIR spectroscopy at a low level for the prediction of Brix significantly improved the prediction accuracy to R²_P = 0.94 and RMSE_P= 0.74. The medium-level data fusion resulted in R²_P = 0.89 and RMSE_P = 0.93 for prediction of water content.
Conclusion
In this study, the accuracy of using Vis-SWNIR and dielectric spectroscopy data for predicting Brix and water content in sugarcane stalk samples was evaluated. To develop the prediction models, partial least squares (PLS) regression and artificial neural network (ANN) were compared. First, the prediction models were developed based on Vis-SWNIR and dielectric spectroscopy independently. Then, the two techniques were fused and the improvement in the prediction accuracy was investigated. Fusing the two methods at an intermediate level lowered the RMSE of Brix to 0.74, showing noticeable improvement compared to previous studies. Based on the achieved results, developing a fusion probe for SWNIR and dielectric spectroscopy and designing the measuring system could be the aim of future studies for in-situ evaluation of sugarcane quality parameters. Due to the importance of sugarcane quality evaluation, during growth and maturity, the results of this study can have a significant role in the development of a portable device that combines NIR and dielectric spectroscopy methods for fast and non-destructive evaluation of sugarcane quality parameters.
Acknowledgment
This article was extracted from a research project financially supported by the Research deputy of Shahrekord University. The grant number was 0GRD34M1614. The authors would like to appreciate the support of the Amir-Kabir Sugarcane Agro-Industry Co., Khuzestan, Iran for providing the sugarcane stalk samples.

Keywords

• Brix
• Data fusion
• Dielectric spectroscopy
• Sugarcane
• Visible-Near infrared spectroscopy

Main Subjects

• Precision Farming

©2024 The author(s). This is an open access article distributed under Creative Commons Attribution 4.0 International License (CC BY 4.0)

References

1. Aldeza, C. G., Botella, M., Toldr, P., & Fito, P. (2010). Low frequency dielectric spectrum to determine pork meat quality. Innovative Food Science and Emerging Technologies, 11(2), 376-386. https://doi.org/10.1016/j.ifset.2010.01.011
2. Anonymous. (2018). Agriculture– Iran– Statistics: Agriculture Agricultural census. 2016-2017, 1, 47-48. (in Persian).
3. Augusto, P., & Filho, C. (2009). Rapid determination of sucrose in chocolate mass using near infrared Analytica Chimica Acta, 631, 206-211. https://doi.org/10.1016/J.ACA.2008.10.049
4. Bahrami, M. E., Honarvar, M., Ansari, K., & Jamshidi, B. (2020). Measurement of quality parameters of sugarbeet juices using near-infrared spectroscopy and chemometrics. Journal of Food Engineering, 271, 109775. https://doi.org/10.1016/j.jfoodeng.2019.109775
5. Bagherpour, H., Minaei, H., Abdollahian Noghabi, M., & Khorasani Fardvani, M. E. (2015). Non-destructive determination of sugar content in root beet by near infrared spectroscopy (NIRS). Food Science and Technology, 46(12), 219-228. (in Persian with English abstract).
6. Biancolillo, A., Bucci, R., & Marini, F. (2014). Data-fusion for multiplatform characterization of an Italian craft beer aimed at its authentication. Analytica Chimica Acta, 820, 23-31. https://doi.org/10.1016/j.aca.2014.02.024
7. Blakey, R. T., & Morales-Partera, A. M. (2016). Microwave dielectric spectroscopy– A versatile methodology for online, non-destructive food analysis, monitoring and process control. Engineering in Agriculture, Environment and Food, 9(3), 264-273. https://doi.org/10.1016/j.eaef.2016.02.001
8. Bobelyn, E., Serban, A. S., Nicu, M., Lammertyn, J., Nicoli, B. M., & Saeys, W. (2010). Postharvest quality predicted by NIR-spectroscopy: Study of the effect of biological variability on spectra and model performance. Postharvest Biology and Technology, 55(3), 133-143. https://doi.org/10.1016/j.postharvbio.2009.09.006
9. Borras, E., Ferre, J., Boque, R., Mestres, M., Acena, L., & Busto, O. (2015). Data fusion methodologies for food and beverage authentication and quality assessment–A Review. Analytica Chimica Acta, 891(3), 1-14. https://doi.org/10.1016/j.aca.2015.04.042
10. Castanedo, F. (2013). A Review of Data Fusion Techniques. Hindawi Publishing Corporation, 2013, 1-19.
11. Chiatrakul, J., Terdwongworakul, A., Phuangsombut, K., & Phuangsombut, A. (2022). Improved evaluation of commercial cane sugar content in sugarcane stalk using near infrared hyperspectral imaging and stalk axis rotation technique. Biosystems Engineering, 223, 161-173. https://doi.org/10.1016/j.biosystemseng.2022.08.019
12. Choi, J. H., Chen, P. A., Lee, B., & Yim, S. H. (2017). Portable, non-destructive tester integrating VIS/NIR reflectance spectroscopy for the detection of sugar content in Asian pears. Scientia Horticulturae, 220(16), 147-153. https://doi.org/10.1016/j.scienta.2017.03.050
13. Cole, M. R., Eggleston, G., Gilbert, A., & Chung, Y. J. (2016). Development of an analytical method to measure insoluble and soluble starch in sugarcane and sweet sorghum products. Food Chemistry, 190, 50-59. https://doi.org/10.1016/j.foodchem.2015.05.049
14. FAO. (2021). Food and Agricultural Organization of United Nations. Statistical Yearbook 2021. Rome. https://doi.org/10.4060,cb4477en
15. Fazayeli, A., Kamgar, S., Nassiri, S. M., Fazayeli, H., & Guardia, M. D. L. (2019). Dielectric spectroscopy as a potential technique for prediction of kiwifruit quality indices during storage. Information Processing in Agriculture, 6(4), 479-486. https://doi.org/10.1016/j.inpa.2019.02.002
16. Fu, X., Ying, Y., Lu, H., Xu, H., & Yu, H. (2007). FT-NIR diffuse reflectance spectroscopy for kiwifruit firmness detection. Sensing and Instrumentation for Food Quality and Safety, 1, 29-35. https://doi.org/10.1007/s11694-007-9004-2
17. Gaci, ,Garcia, S. M.,  Abdelghafour, F., Adrian, J., Maupas, F., & Roger, J. M. (2022). Assessing the potential of a handheld visible-near infrared microspectrometer for sugar beet phenotyping. Journal of Near Infrared Spectroscopy, 30(3), 122-129. https://doi.org/10.1177/09670335221083448
18. Garcia, A., Torres, J. L., De Blas, M., De Francisco, A., & Illanes, R. (2004). Dielectric characteristics of grape juice and wine. Journal of Biosystems Engineering, 88(3), 343-349. https://doi.org/10.1016/j.biosystemseng.2004.04.008
19. Ghasemi-Varnamkhasti, M., Ghatreh-Samani, N., Naderi-Boldaji, M., Forina, M., & Bonyadian, M. (2017). Development of two dielectric sensors coupled with computational techniques for detecting milk adulteration. Computers and Electronics in Agriculture, 140, 266-278. https://doi.org/10.1016/j.compag.2017.06.005
20. Goodarzi, N., Movahhed, S., Shakouri, M. J., & Ahmadi Chenarbon, H. (2022). Feasibility of Visible/Near Infrared (Vis/NIR) Spectroscopy capability in classification of lemon samples during storage period by PCA, LDA and SVM identification methods. Iranian Journal of Food Science and Technology, 18, 335-352. https://doi.org/10.52547/fsct.18.120.26
21. Guo, W., Nelson, S. O., Trabelsi, S., & Kays, S. J. (2007). Dielectric properties of honeydew melons & correlation with quality. Microwave Power & Electromagnetic Energy, 41(2), 4454. https://doi.org/10.1080/08327823.2006.11688556
22. Guo, W., Zhu, X., Liu, Y., & Zhuang, H. (2010). Sugar and water contents of honey with dielectric property sensing. Journal of Food Engineering, 97(2), 275-281. https://doi.org/10.1016/j.jfoodeng.2009.10.024
23. Heise, H. M., & Winzen, R. (2006). Chemometrics in Near-Infrared Spectroscopy. In: Siesler, H. W., Ozaki, Y., Kawata, S. and Heise, H. M. (Eds.) Near-Infrared Spectroscopy: Principles, Instruments, Applications. 3rd Reprint. WileyVCH. Germany.
24. Hoog, N. A., Olthuis, W., Mayer, M. J. J., Yntema, D., Miedema, H., & van den Berg, A. (2012). Online fingerprinting of fluids using coaxial stub resonator technology. Sensors and Actuators, B: Chemical, 163(1), 90-96. https://doi.org/10.1016/j.snb.2012.01.012
25. Jamshidi, B., Minaei, S., Mohajerani, E., & Ghassemian, H. (2012). Reflectance Vis/NIR spectroscopy for nondestructive taste characterization of Valencia oranges. Computers and Electronics in Agriculture, 85, 64-69. https://doi.org/10.1016/j.compag.2012.03.008
26. Jamshidi, B., Minaei, S., Mohajerani, E., & Ghassemian, H. (2014). Effect of spectral pre-processing methods on non-destructive quality assessment of oranges using NIRS. Journal of Agricultural Engineering Research, 167, 264-271. (in Persian with English abstract). https://doi.org/10.22092/JAER.2014.100188
27. Korel, F., Luzuriaga, D., & Balaban, M. O. (2001). Objective quality assessment of raw tilapia (Oreochromis niloticus) fillets using electronic nose and machine vision. Journal of Food Science, 66(7), 1018-1024.
28. Lal Mathur, R. B. (1990). Handbook of cane sugar technology. Oxford & Ibh Publishing Co. India. pp:11.
29. Langford, V. S., McKinley, A. J., & Quickenden, T. I. (2001). Temperature Dependence of the Visible-Near-Infrared Absorption Spectrum of Liquid Water. Journal of Physical Chemistry A, 105, 8916-8921. https://doi.org/10.1021/jp010093m
30. Luzuriaga, D. A. (1999). Application of computer vision and electronic nose technologies for quality assessment of color and odor of shrimp and salmon. PhD dissertation, Department of Food Science and Technology, University of Florida, Gainesville, FL.
31. Magalhaes, P. S. G., & Cerri, D. G. P. (2007). Yield monitoring of sugar cane. Biosystems Engineering, 96(1), 1-6. https://doi.org/10.1016/j.biosystemseng.2006.10.002
32. Magwaza, L. S., Opara, U. L., Terry, L. A., Landahl, S., Cronje, P. J. R., Nieuwoudt, H. H., Hanssens, A., Saeys, W., & Nicolaï, B. M. (2013). Evaluation of Fourier transform-NIR spectroscopy for integrated external and internal quality assessment of Valencia oranges. Journal of Food Composition and Analysis, 31(1), 144-154. https://doi.org/10.1016/j.jfca.2013.05.007
33. Mehrotra, R., & Siesler, H. W. (2003). Application of mid infrared/near infrared spectroscopy in sugar industry. Applied Spectroscopy Reviews, 38(3), 307-354. https://doi.org/10.1081/ASR-120024392
34. Mireei, S. A., Mohtasebi, S. S., Masoodi, R., Rafiei, S. H., & Arabanian, A. S. (2010). Application of FT-NIR spectroscopy in nondestructive maturity determination of Shahani date fruit. Iranian Journal of Biosystem Engineering, 41(2), 113-120. (in Persian with English abstract).
35. Mireei, A., Bagheri, R., Sadeghi, M., & Shahraki, A. (2016). Developing an electronic portable device based on dielectric power spectroscopy for non-destructive prediction of date moisture content. Sensors and Actuators A: Physical, 247, 289-297. https://doi.org/10.1016/j.sna.2016.06.012
36. Moomkesh, S., Mireei, S. A., Sadeghi, M., & Nazeri, M. (2017). Non-destructive prediction of quality parameters of sweet lemon (Citrus limetta) by Vis-SWNIR spectroscopy. Iranian Journal of Biosystems Engineering, 47(4), 603-613. (in Persian with English abstract). https://doi.org/10.22059/IJBSE.2017.61991
37. Naderi-Boldaji, M., Fazelian-Dehkordi, M., Mireei, A., & Ghasemi-Varnamkhasti, M. (2015). Dielectric power spectroscopy as a potential technique for the non-destructive measurement of sugar concentration in Journal of Biosystems Engineering, 140, 1-10. https://doi.org/10.1016/j.biosystemseng.2015.09.003
38. Naderi-Boldaji, M., Mishra, P., Ahmadpour-Samani, M., Ghasemi-Varnamkhasti, M., Ghanbarian, D., & Izadi, Z. (2018). Potential of two dielectric spectroscopy techniques and chemometric analyses for detection of adulteration in grape syrup. Measurement, 127, 518-524. https://doi.org/10.1016/j.measurement.2018.06.015
39. Nawi, M. N., Chen, G., Jensen, T., & Mehdizadeh, S. A. (2013). Prediction and classification of sugar content of sugarcane based on skin scanning using visible and shortwave near infrared. Biosystems Engineering, 115(2), 151-161. https://doi.org/10.1016/j.biosystemseng.2013.03.005
40. Nawi, N. M., Jensen, T., & Chen, G. (2012). The application of spectroscopic methods to predict sugarcane quality based on stalk cross-sectional scanning. Journal of American Society of Sugar Cane Technologists, 32, 16-27.
41. Nelson, S. O. (2004). Agricultural applications of dielectric spectroscopy. Journal of Microwave Power and Electromagnetic Energy, 39(2), 75-85. https://doi.org/10.1080/08327823.2004.11688510
42. Pan, L., Zhu, Q., Lu, R., & McGrath, J. M. (2015). Determination of sucrose content in sugar beet by portable visible and near-infrared spectroscopy. Journal of Agriculture and Food Chemistry, 167(15), 264-271. https://doi.org/10.1016/j.foodchem.2014.06.117
43. Pandiselvam, R., Prithviraj, V., Manikantan, M. R., Kothakota, A., Rusu, A. V., Trif, M., & Khaneghah, M. (2022). Recent advancements in NIR spectroscopy for assessing the quality and safety of horticultural products: A comprehensive review. Frontiers in Nutrition, 9, 973457. https://doi.org/10.3389/fnut.2022.973457
44. Peirs, A., Lam mertyn, J., Ooms, K., & Nicolaı, B. M. (2001). Prediction of the optimal picking date of different apple cultivars by means of VIS: NIR-spectroscopy. Postharvest Biology and Technology, 21(2), 189-199. https://doi.org/10.1016/S0925-5214(00)00145-9
45. Rudnitskaya, A., Kirsanov, D., Legin, A., Beullens, K., Lammertyn, J., & Nicolaï, B. M. (2006). Analysis of apples varieties– Comparison of electronic tongue with different analytical techniques. Sensors and Actuators B: Chemical, 116(1-2), 23-28. https://doi.org/10.1016/j.snb.2005.11.069
46. Sanaeifar, A., Jafari, A., & Golmakani, M. T. (2018). Fusion of dielectric spectroscopy and computer vision for quality characterization of olive oil during storage. Computers and Electronics in Agriculture, 145, 142-152. https://doi.org/10.1016/j.compag.2017.12.035
47. Sirisomboon, P. (2018). NIR spectroscopy for quality evaluation of fruits and vegetables. Materials Today: Proceedings, 5(10), 22481-22486. https://doi.org/10.1016/j.matpr.2018.06.619
48. Skierucha, W., Wilczek, A., & Szypowska, A. (2012). Dielectric spectroscopy in agrophysics. International Agrophysics, 26, 187-197. https://doi.org/10.2478/v10247-012-0027-5
49. Soltani, M., Alimardani, R., & Omid, M. (2011). Evaluating banana ripening status from measuring dielectric properties. Journal of Food Engineering, 105(4), 625-631. https://doi.org/10.1016/j.jfoodeng.2011.03.032
50. Xiaobo, Z., Jiewen, Z., Xingyi, H., & Yanxiao, L. (2007). Use of FT-NIR spectrometry in non-invasive measurements of soluble solid contents (SSC) of 'Fuji' apple based on different PLS models. Chemometrics and Intelligent Laboratory Systems, 87(1), 43-51. https://doi.org/10.1016/j.chemolab.2006.09.003